低壓脈沖布袋除塵器，麥迪脈沖除塵器
LMCD(CDMC)系列長袋脈沖布袋式除塵器
LMCD (CDMC) Series Long-Bag Pulse Bag Pulse Filter
低壓脈沖布袋除塵器，麥迪脈沖除塵器
【特點簡介Characteristics】
- 設計新穎，采用下進氣結構，較粗的高溫顆粒直接落入灰斗，有效的保護了濾袋
- 采用長濾袋，在同等處理能力時設備占地面積少，更便于老廠改造
- 采用分室離線清灰，效率高，粉塵的二次吸附少，同時有效的降低了設備能耗，濾袋與脈沖閥的疲勞程度也相應降低，成倍地提高了濾袋和閥片的壽命，大量減少了設備運行維護的費用
- 檢修換袋可在不停系統風機、系統正常運行的條件下分室進行
- 濾袋袋口采用彈簧漲緊結構，拆裝方便，具有良好的密封性
- 箱體經過氣密性設計，并以煤油撿漏，zui大程度減少漏風
- 整臺設備由PLC機控制，實現自動清灰、卸灰、自動溫度控制及超溫報警
- Hopper directly to effectively protect filter bags.
- With long bags, equipment takes less area compared with others in the same capacity. It is especially favorable for upgrading of existing plants.
- Off-line dust removal in separate chambers featured as follows: high efficiency: less secondary dust re-adhering: lower power consumption; extended service life of bags and valve plate due to less fatigue. in this way, expense for equipment maintenance could be greatly reduced.
- Maintenance and replacement of bag can be separay conducted in each chamber without interrupting the whole operation system and fans.
- Apply spring take-up at bag mouth for easy maintenance and replacement and favorable air tightness.
- The design of shell takes air tightness into consideration and use kerosene for inspection, so as to reduce air leakage to the largest extent.
- Equipment is controlled through PLC to realize automatic dust removal, dust discharge, temperature control and over-temperature alarming.
- 【技術指標Technical indexes】
- 排放低于30mg/Nm³
- 濾袋平均壽命在18個月以上
- 運轉率相對主機*
- Emission concentration is below 30 mg/Nm³.
- The average life service is over 18 months.
The operation rate of dust collector to man equipment is *
